humiDisk65 is a small humidifier that uses a spinning disk to atomise the water
and transform it into millions of very small drops that, blown by a built-in
fan, are introduced into the environment, where they evaporate, humidifying
and cooling the air.
This is a simple, economic and easy to maintain humidification system, with
an energy consumption of just 220 W per 6.5 kg/h of capacity.
The water tank inside the humiDisk65 contains just 0.055 litres of water, which
is atomised, at maximum capacity, in just 30s. The water in the tank is therefore
changed 120 times per hour, meaning the humidifier substantially works with
running water, so as to guarantee the best hygiene conditions.
The operation of the humidifier is controlled by an electronic board inside
the humidifier that, as well as managing the normal operation of the appliance,
also performs a tank washing cycle when starting the unit, and an emptying cycle
at the end of the humidification request. This avoids having stagnated water
inside the unit.
IMPORTANT: to ensure a higher level of hygiene, when using
the CAREL electrical control panels, the humidifier also washes the water tank
at the start of each humidification cycle.
The electronic board also features a trimmer to set the capacity of the humidifier.
Electrical panels
Each humiDisk65 centrifugal humidifier must be connected to an electrical control
panel, supplied by CAREL, for the control of one or two humidifiers in parallel.
The humidity probe, supplied separately, can be connected to the electrical
panel, which then manages the humidifier so as to maintain the air humidity
at the desired level.
Antifreeze device
humiDisk65 can be supplied with an optional antifreeze device: an electric immersion
heater, controlled by the electronic board and a temperature sensor that is
activated when the temperature inside the unit approaches 0 °C.
The appliance can operate at temperatures down to around 1 °C without the
antifreeze device, and down to -2 °C with the device (optional)..
Water used
humiDisk65 operate on both mains water or treated water (see the technical specifications).
ADVANTAGES
• simplicity: requires just the
230 Vac power supply and the mains water and drain lines. Operation is
ON/OFF;
• hygienically safe:
- very small water tank, only 55 millilitres!;
- washing procedure at unit start;
- washing procedure at the beginning of every cycle (with CAREL control
panel only).
• modularity: 1 or 2 humiDisk65
units can be controlled in parallel using the special control panel supplied
by CAREL.
